[1]周强泰,赵伶玲.考虑辐射强度沿截面方向减弱的炉内传热公式[J].东南大学学报(自然科学版),2008,38(6):1004-1010.[doi:10.3969/j.issn.1001-0505.2008.06.014]
 Zhou Qiangtai,Zhao Lingling.Study on radiation heat transfer in boiler furnaces by taking radiant intensity attenuation in cross section into consideration[J].Journal of Southeast University (Natural Science Edition),2008,38(6):1004-1010.[doi:10.3969/j.issn.1001-0505.2008.06.014]
点击复制

考虑辐射强度沿截面方向减弱的炉内传热公式()
分享到:

《东南大学学报(自然科学版)》[ISSN:1001-0505/CN:32-1178/N]

卷:
38
期数:
2008年第6期
页码:
1004-1010
栏目:
能源与动力工程
出版日期:
2008-11-20

文章信息/Info

Title:
Study on radiation heat transfer in boiler furnaces by taking radiant intensity attenuation in cross section into consideration
作者:
周强泰 赵伶玲
东南大学能源与环境学院, 南京 210096
Author(s):
Zhou Qiangtai Zhao Lingling
School of Energy and Environment, Southeast University, Nanjing 210096, China
关键词:
辐射传热 辐射强度 辐射减弱 煤粉锅炉 炉膛火焰
Keywords:
radiation heat transfer radiation intensity radiation attenuation pulverized coal fired boilers furnace flame
分类号:
TK222
DOI:
10.3969/j.issn.1001-0505.2008.06.014
摘要:
分析了以2个平行平面辐射换热公式作为蒸汽锅炉炉内火焰对四周水冷壁进行辐射传热计算的基本公式,该式是在炉膛截面各处温度相同、从炉膛中心到四周水冷壁平面不发生辐射强度任何减弱的前提下获得的,因此,计算偏差在所难免.假设炉膛为横截面积和高度与近似矩形立方体的炉膛横截面积和高度相同的当量圆柱体,以辐射强度沿射线行程变化的能量方程,推导出一维(横截面的径向)的辐射能在从炉膛中心向四周壁面传递时因火焰介质的吸收、自身辐射和散射作用造成的辐射强度的减弱,并在此基础上推导出考虑了辐射能沿截面方向从炉膛中心向四周壁面减弱后的炉内辐射传热公式.分析了所得公式的特点和适用性.所提出的公式和现有某些计算方法,对大型煤粉电站锅炉燃用含灰量不同的3种典型烟煤时分别进行了炉膛出口烟温的计算,并进行了比较,分析了这些方法存在的不足.
Abstract:
Using the radiation heat transfer formula between two infinite parallel plates as the basic method to calculate the radiation heat transfer from the furnace flame to the surrounded furnace water wall of steam boilers is analyzed in this paper. Since the basic condition assumes the flame temperature to be uniform elsewhere in the cross section of the furnace and without any attenuation of radiation intensity from the furnace central line to the surrounded water wall, the deviation of the calculation results is unavoidable. The calculation formula of furnace radiation heat transfer in the 1973-normative method of pre-Russia has the same necessary condition as that of two infinite parallel plate formula. Assuming that the boiler furnace is cylindrical with the identity of the cross sectional area and the height, based on the radiant energy transfer equation mentioned by Robert Siegel, and taking account of the medium absorption, emission and scattering along the path of the radiation ray, the one dimensional equation of the radiation intensity attenuation from the furnace centre to the surrounded water wall has been derived in this paper, and furthermore, the radiation heat transfer calculation formula for the furnace flame of pulverized-coal steam boilers has been obtained. The characteristics of the obtained formula and its suitability for the radiation heat transfer calculation of steam boilers furnaces are analyzed.The obtained formula has been used to calculate the furnace exit flue gas temperature for the modern power plant boilers burned with different ash contents of three typical bituminous coals and the results are compared with those of some other calculation methods and the comment on the relevant calculation methods is made.

参考文献/References:

[1] Anon.Thermal calculation of boiler units(normative method)[M].Moscow:Energiya Press,1973.(in Russian)
[2] Dubovsky Yu E,Blokh A G.Accurate calculation of heat transfer and selection of wall heat flux in boiler furnace with large capacity[J]. Teploenergetika,1987(1):22-25.(in Russian)
[3] Blockh A G. Heat transfer in furnaces of steam boilers[M].Leningrad:Energy atomic Press,1984.(in Russian)
[4] Zhuravlev Yu A,Spichak I V,Protsailo M Ya.Heat transfer in boiler furnace,taking account of the scattering of radiation,engineering—physical[M].New York:Plenum Publishing Corporation,1983:541-548.
[5] Antonovsky V Yu.Heat transfer in furnaces of steam boilers,the review of normative calculation method in retrospect[J]. Teploenergetika,2004(9):53-62.(in Russian)
[6] Siegel R,Howell J R. Thermal radiation heat transfer[M].2nd ed.Washington:Hemisphere and McGraw-Hill,1981.
[7] Rohsenow W M,Hartnett J P,Ganic E N.Handbook of heat transfer fundamentals [M].2nd ed.New York:McGraw-Hill Book Company,1985.
[8] Blokh A G,Zhuravlev Yu A,Gorb E I,et al.Heat transfer in furnaces of high-power boilers[J]. Heat Transfer Research,1993,25(3):418-424.
[9] 王致均.锅炉炉内过程[M].重庆:科学技术文献出版社重庆分社,1980.
[10] 胡荫平.电站锅炉手册[M].北京:中国电力出版社,2005.
[11] 秦裕坤.炉内传热[M].北京:机械工业出版社,1981.

备注/Memo

备注/Memo:
作者简介: 周强泰(1935—),男,教授,博士生导师.
引文格式: 周强泰,赵伶玲.考虑辐射强度沿截面方向减弱的炉内传热公式[J].东南大学学报:自然科学版,2008,38(6):1004-1010.
更新日期/Last Update: 2008-11-20