[1]仲兆平,梁秀进,金保升,等.乙酸钠添加剂对NOxOUT工艺影响的试验研究[J].东南大学学报(自然科学版),2010,40(5):997-1002.[doi:10.3969/j.issn.1001-0505.2010.05.022]
 Zhong Zhaoping,Liang Xiujin,Jin Baosheng,et al.Experimental study of influence of sodium acetate additive to NOxOUT process[J].Journal of Southeast University (Natural Science Edition),2010,40(5):997-1002.[doi:10.3969/j.issn.1001-0505.2010.05.022]
点击复制

乙酸钠添加剂对NOxOUT工艺影响的试验研究()
分享到:

《东南大学学报(自然科学版)》[ISSN:1001-0505/CN:32-1178/N]

卷:
40
期数:
2010年第5期
页码:
997-1002
栏目:
环境科学与工程
出版日期:
2010-09-20

文章信息/Info

Title:
Experimental study of influence of sodium acetate additive to NOxOUT process
作者:
仲兆平 梁秀进 金保升 陈晓林 张居兵
东南大学能源与环境学院,南京 210096
Author(s):
Zhong Zhaoping Liang Xiujin Jin Baosheng Chen Xiaolin Zhang Jubing
School of Energy and Environment, Southeast University, Nanjing 210096,China
关键词:
NOxOUT 脱硝 乙酸钠添加剂 烟气碱性
Keywords:
NOxOUT denitrification sodium acetate additive flue gas alkaline
分类号:
X51
DOI:
10.3969/j.issn.1001-0505.2010.05.022
摘要:
在自行研制的选择性非催化还原(SNCR)脱硝实验台上进行了乙酸钠作添加剂对NOxOUT工艺影响的实验研究.无添加剂时,尿素对NO的去除效果良好,在最优温度(900 ℃)条件下氨氮比(摩尔比)为1.5时NO的去除率可达76.56%,但会生成大量的N2O,极大地降低了NOx的总去除率.加入乙酸钠,在较低温度条件下,NO含量随着其添加量的增大呈先降低后升高的趋势,在较高温度条件下,呈现升高后降低的趋势; 而N2O含量在各温度条件下随着乙酸钠添加量的增大一直呈降低趋势直至为零.随着乙酸钠添加量的增大,N2O对NOx总去除率的不利影响逐渐降低,当摩尔比n(CH3COONa)/n(NOx)=0.44时,825~925℃区间内总NOx去除率在65%以上.乙酸钠作添加剂拓宽了工艺的温度窗口,去除了尿素还原NOx时所生成的N2O,极大地提高了总的NOx去除率.由于钠盐主要是以NaNCO形式存在,所以添加乙酸钠所引起的烟气碱性增大的程度并不严重.
Abstract:
Experimental study of the influence of sodium acetate on NOxOUT process was carried out on self-made SNCR(selective non-catalytic reduction)reactor. The experimental results show that NO removal efficiency at optimum temperature(900 ℃)achieves 76.56% with a molar ratio of n(0.5CO(NH2)2)/n(NOx)=1.5 without additives, but the production of a large amount of N2O decreases NOx removal efficiency seriously. With the increase of sodium acetate, the content of NO decreases first and then increases at lower temperatures and increases first and then decreases at higher temperatures; while the content of N2O decreases at all temperatures in the temperature window. With the increase of sodium acetate, the adverse effect of N2O on total NOx removal efficiency decreases and total NOx removal efficiency at temperature 825 to 925 ℃ achieves above 65% with n(CH3COONa)/n(NOx)=0.44. The addition of sodium acetate widens the temperature window of the process and improves NOx removal efficiency significantly through the removal of N2O. The addition of sodium acetate causes the flue gas to be alkaline, but it is not serious since sodium salt mainly exists as NaNCO.

参考文献/References:

[1] 吕洪坤,杨卫娟,周志军,等.选择性非催化还原法在电站锅炉上的应用[J].中国电机工程学报,2008,28(23):14-19.
  Lü Hongkun,Yang Weijuan,Zhou Zhijun,et al.Application of selective non-catalytic reduction on a power plant boiler [J]. Proceedings of the CSEE,2008,28(23):14-19.(in Chinese)
[2] 周俊虎,卢志民,王智化,等.2.11兆瓦燃煤四角炉喷氨水脱硝试验[J].浙江大学学报:工学版,2006,40(6):961-965.
  Zhou Junhu,Lu Zhimin,Wang Zhihua,et al.NOx reduction by aqua ammonia injection at 2.11 MW tangential pulverized fired boiler [J].Journal of Zhejiang University: Engineering Science,2006,40(6):961-965.(in Chinese)
[3] Rota Renato,Antos Dorota,Zanoelo Everton F,et al.Experimental and modeling analysis of the NOxOUT process [J]. Chemical Engineering Science, 2002,57(1):27-38.
[4] 卢志民,周俊虎,王智化,等.碳酸氢铵选择性非催化还原烟气中的氮氧化物[J].燃烧科学与技术,2005,11(6):511-514.
  Lu Zhimin,Zhou Junhu,Wang Zhihua,et al.Selective non-catalytic reduction of NOx in the flue gas by ammonium bicarbonate solution[J].Journal of Combustion Science and Technology,2005,11(6):511-514.(in Chinese)
[5] 梁秀进,仲兆平,金保升,等.CH4作添加剂对SNCR脱硝工艺的影响[J].东南大学学报:自然科学版,2009,39(3):629-634.
  Liang Xiujin,Zhong Zhaoping,Jin Baosheng,et al.Influence of CH4 additive on SNCR process [J]. Journal of Southeast University:Natural Science Edition,2009,39(3):629-634.(in Chinese)
[6] Lee Seungmoon,Park Kwinam,Park Jin-Won,et al.Characteristics of reducing NO using urea and alkaline additives [J].Combustion and Flame,2005,141(3):200-203.
[7] 高亮,王智化,凌忠钱,等.炉内高温喷射尿素溶液脱硝机理及其影响因素[J].锅炉技术,2005,36(2):72-75.
  Gao Liang,Wang Zhihua,Ling Zhongqian,et al.Mechanism and parameters study on NOx abatement use urea as agent in boiler [J]. Boiler Technology,2005,36(2):72-75.(in Chinese)
[8] 周俊虎,杨卫娟,周志军,等.选择非催化还原过程中的N2O生成与排放[J].中国电机工程学报,2005,25(13):91-95.
  Zhou Junhu,Yang Weijuan,Zhou Zhijun,et al.Nitrous oxide formation and emission in selective non-catalytic reduction process [J]. Proceedings of the CSEE,2005,25(13):91-95.(in Chinese)
[9] Zamansky Vladimir M,Lissianski Vitali V,Maly Peter M,et al.Reactions of sodium species in the promoted SNCR process [J].Combustion and Flame,1999,117(4):821-831.
[10] Han Kuihua,Lu Chunmei.Kinetic model and simulation of promoted selective non-catalytic reduction by sodium carbonate [J].Chin J Chern Eng,2007,15(4):512-519.
[11] 吕洪坤,杨卫娟,周俊虎,等.化学计量比、雾化压力对电站锅炉SNCR脱硝的影响[J].化工学报,2008,59(11):2898-2903.
  Lü Hongkun,Yang Weijuan,Zhou Junhu,et al.Impact of NSR and atomization pressure on SNCR used in power plant boiler [J].Journal of Chemical Industry and Engineering,2008,59(11):2898-2903.(in Chinese)
[12] Sarantuyaa Zandaryaa,Renato Gavasci,Francesco Lombardi,et al.Nitrogen oxides from waste incineration:control by selective non-catalytic reduction [J]. Chemosphere,2001,42(11):491-497.

相似文献/References:

[1]陶贺,金保升,朴桂林,等.活性焦烟气脱硫脱硝的静态实验和工艺参数选择[J].东南大学学报(自然科学版),2009,39(3):635.[doi:10.3969/j.issn.1001-0505.2009.03.040]
 Tao He,Jin Baosheng,Piao Guilin,et al.Static experiment and technology parameter study of flue gas desulphurization and denitrification by active coke[J].Journal of Southeast University (Natural Science Edition),2009,39(5):635.[doi:10.3969/j.issn.1001-0505.2009.03.040]
[2]朱崇兵,金保升,仲兆平,等.K2O对V2O5-WO3/TiO2催化剂的中毒作用[J].东南大学学报(自然科学版),2008,38(1):101.[doi:10.3969/j.issn.1001-0505.2008.01.020]
 Zhu Chongbing,Jin Baosheng,Zhong Zhaoping,et al.Poisoning effect of K2O on V2O5-WO3/TiO2 catalysts[J].Journal of Southeast University (Natural Science Edition),2008,38(5):101.[doi:10.3969/j.issn.1001-0505.2008.01.020]
[3]梁辉,归柯庭.纳米γ Fe2O3催化剂SCR脱除NOxx化学反应动力学[J].东南大学学报(自然科学版),2015,45(5):918.[doi:10.3969/j.issn.1001-0505.2015.05.017]
 Liang Hui,Gui Keting.Chemical reaction kinetics of SCR of NOxx over γ Fe2O3 nano-catalyst[J].Journal of Southeast University (Natural Science Edition),2015,45(5):918.[doi:10.3969/j.issn.1001-0505.2015.05.017]

备注/Memo

备注/Memo:
作者简介: 仲兆平(1965—),男,教授,博士生导师,zzhong@seu.edu.cn.
基金项目: 国家高技术研究发展计划(863计划)资助项目(2008AA05Z303)、国家自然科学基金资助项目(50776019)、教育部新世纪优秀人才支持计划资助项目(NCET-05-0469).
引文格式: 仲兆平,梁秀进,金保升,等.乙酸钠添加剂对NOxOUT工艺影响的试验研究[J].东南大学学报:自然科学版,2010,40(5):997-1002. [doi:10.3969/j.issn.1001-0505.2010.05.022]
更新日期/Last Update: 2010-09-20