[1]张军,谢文霞,龚勋.θ环填料塔中灰颗粒对K2CO3溶液吸收CO2性能的影响[J].东南大学学报(自然科学版),2015,45(3):509-514.[doi:10.3969/j.issn.1001-0505.2015.03.017]
 Zhang Jun,Xie Wenxia,Gong Xun.Influence of ash particle on CO2 absorption performance using potassium carbonate in a θ-ring packed tower[J].Journal of Southeast University (Natural Science Edition),2015,45(3):509-514.[doi:10.3969/j.issn.1001-0505.2015.03.017]
点击复制

θ环填料塔中灰颗粒对K2CO3溶液吸收CO2性能的影响()
分享到:

《东南大学学报(自然科学版)》[ISSN:1001-0505/CN:32-1178/N]

卷:
45
期数:
2015年第3期
页码:
509-514
栏目:
环境科学与工程
出版日期:
2015-05-20

文章信息/Info

Title:
Influence of ash particle on CO2 absorption performance using potassium carbonate in a θ-ring packed tower
作者:
张军1谢文霞1龚勋2
1东南大学能源转换及过程测控教育部重点实验室, 南京210096; 2华中科技大学煤燃烧国家重点实验室, 武汉430074
Author(s):
Zhang Jun1 Xie Wenxia1 Gong Xun2
1Key Laboratory of Energy Thermal Conversion and Control of Ministry of Education, Southeast University, Nanjing 210096, China
2State Key Laboratory of Coal Combustion, Huazhong University of Science and Technology, Wuhan 430074, China
关键词:
碳酸钾 灰颗粒 二氧化碳 填料塔
Keywords:
potassium carbonate ash particles carbon dioxide packed bed
分类号:
X511
DOI:
10.3969/j.issn.1001-0505.2015.03.017
摘要:
为了解燃煤烟气中灰颗粒对化学吸收法脱除CO2性能的影响,选用典型的K2CO3溶液作为吸收剂,利用乱堆θ环小型填料塔,采用液相加入灰的方式,进行了实验研究. 考察了吸收液温度、填料塔高度、液气比、灰颗粒浓度等工艺条件对灰作用的影响规律.结果表明,灰的存在使脱除CO2的效率降低, 灰对脱除效率降低的影响与其化学成分关系不大,但与操作参数有关; 随着吸收液温度或填料高度的增加,灰对CO2脱除效率的影响减弱;随着液气比的增加,灰对CO2脱除效率的影响有上升的趋势;随着灰颗粒浓度的增大,灰对CO2脱除效率的影响逐渐增大,最后趋于稳定.分析表明,对灰的影响主要是通过改变吸收液初始分布而实现的.
Abstract:
To understand the influence of the ash particles in the flue gas generated from coal combustion on the absorption performance of CO2 by the chemical absorption method, the typical K2CO3 solution was employed as the absorbent, and experiments were carried out by using a small packed absorber filled with θ-ring packing and introducing the ash from the liquid phase. The effects laws of the process conditions, including the absorption liquid temperature, the packing height, the liquid-gas ratio and the concentration of the ash particles, on the ash action were studied. The results show that the existence of the ash can reduce CO2 removal efficiency. The effect of the ash on the removal efficiency is not related to its chemical composition but to the operation parameters. With the increase of the absorption liquid temperature or the packing height, this effect is weakened. With the increase of the liquid-gas ratio, this effect has a tendency to rise. With the increase of the concentration of the ash particles, this effect increases gradually and finally tends to be stable. Therefore, the influence of the ash can be achieved by changing the initial distribution of the absorption liquid.

参考文献/References:

[1] Maheswari A U, Palanivelu K. Absorption of carbon dioxide in alkanolamine and vegetable oil mixture and isolation of 2-amino-2-methyl-1-propanol carbamate[J]. Journal of CO2Utilization2, 2014, 6: 45-52.
[2] Valverde J M, Sanchez-Jimenez P E, Perez-Maqueda L A, et al. Role of crystal structure on CO2 capture by limestone derived CaO subjected to carbonation/recarbonation/calcination cycles at Ca-looping conditions[J]. Applied Energy, 2014,125: 264-275.
[3] Chan Z P, Yusop N M, Abai M, et al. CO2 removal from natural gas using membrane contactor[C]//Proceedings of the Annual Offshore Technology Conference. Kuala Lumpur, Malaysia, USA, 2014, 3: 2242-2248.
[4] 骆培成, 焦真, 张志炳. 填料塔中碳酸钾/哌嗪混合吸收液脱除CO2的体积传质系数[J]. 化工学报, 2005, 56(1): 53-57.
  Luo Peicheng, Jiao Zhen, Zhang Zhibing. Volumetric mass transfer coefficients of dilute CO2 absorption into mixtures of potassium carbonate and piperazine in packed column [J]. Journal of Chemical Industry and Engineering:China, 2005, 56(1): 53-57.(in Chinese)
[5] Hamada M F, Zewail T M, Farag H A. Study of corrosion behaviour of A106 carbon steel absorber for CO2 removal in amine promoted hot potassium carbonate solution(benfield solution)[J]. Corrosion Engineering Science and Technology, 2014, 49(3): 209-218.
[6] 李庆领, 范连翠, 李太星, 等. 操作参数对MEA法捕集CO2吸收过程的影响研究[J]. 太原理工大学学报, 2010, 41(5): 585-588.
  Li Qingling, Fan Liancui, Li Taixing, et al. The effect of operation parameters on CO2absorption rate in M-onoethanolamine(MEA)scrubbing[J]. Journal of Taiyuan University of Technology, 2010, 41(5): 585-588.(in Chinese)
[7] 那艳清, 符开云, 梁志武. θ环填料塔中单乙醇胺吸收CO2传质性能研究[J]. 湖南大学学报:自然科学版, 2011, 38(3): 69-72.
  Na Yanqing, Fu Kaiyun, Liang Zhiwu. Mass transfer performance in a θ-ring packed tower for CO2absorption process using Monoethanolamine(MEA)[J]. Journal of Hunan University:Natural Sciences, 2011, 38(3): 69-72.(in Chinese)
[8] Dey Anindo, Aroonwilas Adisorn. CO2 absorption into MEA-AMP blend: mass transfer and absorber height index[J]. Energy Procedia, 2009, 1(1): 211-215.
[9] 尹文萱, 刘建周, 王志华, 等. 有机胺回收烟道气中二氧化碳的工艺研究[J]. 煤炭工程, 2009(5): 79-81.
  Yin Wenxuan, Liu Jianzhou, Wang Zhihua, et al. Technical study on organic amine to recover CO2 in flue gas [J]. Coal Engineering, 2009(5): 79-81.(in Chinese)
[10] Kemper J, Ewert G, Grünewald M. Absorption and regeneration performance of novel reactive amine solvents for post-combustion CO2 capture[J]. Energy Procedia, 2011, 4: 232-239.
[11] Bonenfant D, Mimeault M, Hausler R. Estimation of the CO2 absorption capacities in aqueous 2-(2-Aminoethylamino)ethanol and its blends with MDEA and TEA in the presence of SO2[J]. Industrial & Engineering Chemistry Research, 2007, 46(26): 8968-8971.
[12] Usubharatana P, Tontiwachwuthikul P. Enhancement factor and kinetics of CO2 capture by MEA-methanol hybrid solvents[J]. Energy Procedia, 2009, 1(1): 95-102.
[13] Chen Z, Yates D, Neathery J, et al. The effect of fly ash on fluid dynamics of CO2 scrubber in coal-fired power plant[J]. Chemical Engineering Research and Design, 2012, 90(3): 328-335.
[14] 张军, 徐益谦. 风化粉煤灰pH值变化特征[J].粉煤灰, 2004, 16(5): 15-16.
  Zhang Jun, Xu Yiqian. The characteristic of weathered-fly ash pH value change [J]. Coal Ash China, 2004, 16(5): 15-16.(in Chinese)
[15] 许洁, 奚安, 张成芳. K2CO3溶液脱除CO2最佳浓度的研究[J]. 天然气化工, 2009, 34(4): 17-19.
  Xu Jie, Xi An, Zhang Chengfang. An investigation on the optimum concentration of potassium carbonate aqueous solution for removal of carbon dioxide [J]. Natural Gas Chemical Industry, 2009, 34(4): 17-19.(in Chinese)
[16] 秦总根,涂伟萍. 填料塔液体分布器的设计与选型[J]. 现代化工, 2003, 23(增刊): 221-227.
  Qin Zonggen, Tu Weiping. Design and type selection of liquid distribution in filling layers of filling column[J]. Modern Chemical Industry, 2003, 23(supp): 221-227.(in Chinese)
[17] 许越. 化学反应动力学[M]. 北京: 化学工业出版社, 2004.

备注/Memo

备注/Memo:
收稿日期: 2014-10-19.
作者简介: 张军(1963—),男,博士,教授,博士生导师,Junzhang@seu.edu.cn.
基金项目: 国家重点基础研究发展计划(973计划)资助项目(2013CB228504)、华中科技大学煤燃烧国家重点实验室开发基金资助项目(FSKLCC1205).
引用本文: 张军,谢文霞,龚勋.θ环填料塔中灰颗粒对K2CO3溶液吸收CO2性能的影响[J].东南大学学报:自然科学版,2015,45(3):509-514. [doi:10.3969/j.issn.1001-0505.2015.03.017]
更新日期/Last Update: 2015-05-20