[1]徐俊超,于燕,张军,等.润湿剂促进细颗粒在水汽条件下长大的实验研究[J].东南大学学报(自然科学版),2017,47(1):67-72.[doi:10.3969/j.issn.1001-0505.2017.01.013]
 Xu Junchao,Yu Yan,Zhang Jun,et al.Experimental study of vapor condensation on fine particles with surfactant addition[J].Journal of Southeast University (Natural Science Edition),2017,47(1):67-72.[doi:10.3969/j.issn.1001-0505.2017.01.013]
点击复制

润湿剂促进细颗粒在水汽条件下长大的实验研究()
分享到:

《东南大学学报(自然科学版)》[ISSN:1001-0505/CN:32-1178/N]

卷:
47
期数:
2017年第1期
页码:
67-72
栏目:
能源与动力工程
出版日期:
2017-01-18

文章信息/Info

Title:
Experimental study of vapor condensation on fine particles with surfactant addition
作者:
徐俊超于燕张军钟辉
东南大学能源热转换及其过程测控教育部重点实验室, 南京 210096
Author(s):
Xu Junchao Yu Yan Zhang Jun Zhong Hui
Key Laboratory of Energy Thermal Conversion Control of Ministry of Education, Southeast University, Nanjing 210096, China
关键词:
润湿剂 细颗粒 水汽 长大
Keywords:
surfactant fine particle water vapor growth
分类号:
TK16
DOI:
10.3969/j.issn.1001-0505.2017.01.013
摘要:
为了研究润湿剂对细颗粒表面润湿性能的改善效果及其促进细颗粒在水汽条件下的长大特性,对添加润湿剂Tween20作用下的细颗粒表面润湿性能进行了测量,并通过在热水中添加润湿剂研究了Tween20对细颗粒在水汽条件下长大的影响.结果表明:Tween20可以有效改善细颗粒表面的润湿性能并促进细颗粒的长大,同时Tween20的添加方式和添加量对促进细颗粒的长大效果都有一定的影响;Tween20的添加浓度不同对细颗粒的长大促进作用机制也不同,在Tween20浓度10~30 g/L的范围内,添加润湿剂有利于细颗粒的长大,但当Tween20的添加浓度超过30 g/L后,添加润湿剂虽然可以提高颗粒长大的最终直径,但是润湿剂的增加并不利于小粒径段(<1 μm)细颗粒的长大,Tween20的浓度为30 g/L时对细颗粒的长大促进效果最优.因此,在应用润湿剂促进细颗粒物长大并脱除时,适量地添加润湿剂才能达到最佳的促进效果.
Abstract:
In order to investigate the improvement effects by surfactant addition and growth characteristics of fine particles under water vapor with surfactant addition, the wetting performance of fine particles with Tween20 addition was measured, and the effect of Tween20 addition on fine particles enlargement under the water vapor was also experimentally studied. The results show that particle surface wetting properties and enlargement can be improved by Tween20 addition, and the addition way and the concentration of Tween20 both have an impact on the particle enlargement. The mechanism that surfactant facilitate particle enlargement varies with its addition concentration. In a certain concentration(10 to 30 g/L), its increase is in favor of particle enlargement, however, when the Tween20 addition concentration is above 30 g/L, the final average diameter of particles after growth increases while the surfactant addition has negative effect on small particle(<1 μm)enlargement. The optical performance of the particle enlargement appears when Tween20 addition is 30 g/L. Therefore, a suitable surfactant addition has the best effect on facilitating particle enlargement and removal.

参考文献/References:

[1] Song Y, Zhang Y H, Xie S D, et al. Source apportionment of PM2.5 in Beijing by positive matrix factorization[J]. Atmospheric Environment, 2006, 40(8): 1526-1537. DOI:10.1016/j.atmosenv.2005.10.039.
[2] Wu S, Deng F, Wei H, et al. Association of cardiopulmonary health effects with source-appointed ambient fine particulate in Beijing, China: A combined analysis from the healthy volunteer natural relocation(HVNR)study[J]. Environmental Science & Technology, 2014, 48(6): 3438-3448. DOI:10.1021/es404778w.
[3] de Joannon M, Cozzolino G, Cavaliere A, et al. Heterogeneous nucleation activation in a condensational scrubber for particulate abatement[J]. Fuel Processing Technology, 2013, 107: 113-118. DOI:10.1016/j.fuproc.2012.10.004.
[4] 徐俊超,张军,于燕,等.细颗粒长大特性的直接测量[J].东南大学学报(自然科学版),2016,46(1):70-75. DOI:10.3969/j.issn.1001-0505.2016.01.012.
  Xu Junchao, Zhang Jun, Yu Yan, et al. Direct measurement of fine particles growth characteristics[J]. Journal of Southeast University(Natural Science Edition), 2016, 46(1): 70-75. DOI:10.3969/j.issn.1001-0505.2016.01.012.(in Chinese)
[5] 凡凤仙,袁竹林.外加声场对增加PM2.5碰撞几率的数值模拟研究[J].中国电机工程学报,2006,26(11):12-16. DOI:10.3321/j.issn:0258-8013.2006.11.003.
  Fan Fengxian, Yuan Zhulin. Numerical simulation of the collision rate of PM2.5 in sound wave field[J]. Proceedings of the CSEE, 2006, 26(11): 12-16. DOI:10.3321/j.issn:0258-8013.2006.11.003.(in Chinese)
[6] Ji J H, Hwang J, Bae G N, et al. Particle charging and agglomeration in DC and AC electric fields[J]. Journal of Electrostatics, 2004, 61(1): 57-68. DOI:10.1016/j.elstat.2003.12.003.
[7] 刘勇,杨林军,潘丹萍,等.化学团聚降低WFGD系统PM2.5排放的试验研究[J].东南大学学报(自然科学版),2015,45(2):320-327. DOI:10.3969/j.issn.1001-0505.2015.02.022.
  Liu Yong, Yang Linjun, Pan Danping, et al. Experimental study on amount reduce of PM2.5 discharged from WFGD by chemical agglomeration[J]. Journal of Southeast University(Natural Science Edition), 2015, 45(2): 320-327. DOI:10.3969/j.issn.1001-0505.2015.02.022.(in Chinese)
[8] Yoshida T, Kousaka Y, Okuyama K, et al. Application of particle enlargement by condensation to industrial dust collection[J]. Journal of Chemical Engineering of Japan, 1978, 11(6): 469-475. DOI:10.1252/jcej.11.469.
[9] Heidenreich S, Ebert F. Condensational droplet growth as a preconditioning technique for the separation of submicron particles from gases[J]. Chemical Engineering and Processing: Process Intensification, 1995, 34(3): 235-244. DOI:10.1016/0255-2701(94)04009-5.
[10] Bao J J, Yang L J, Yan J P, et al. Experimental study of fine particles removal in the desulfurated scrubbed flue gas[J]. Fuel, 2013, 108: 73-79. DOI:10.1016/j.fuel.2010.12.037.
[11] Xu J C, Zhang J, Yu Y, et al. Characteristics of vapor condensation on coal-fired fine particles[J]. Energy & Fuels, 2016, 30(3): 1822-1828. DOI:10.1021/acs.energyfuels.5b02200.
[12] 颜金培,杨林军,沈湘林.燃烧源PM2.5微粒润湿性能[J].东南大学学报(自然科学版),2006,36(5):760-764. DOI:10.3321/j.issn:1001-0505.2006.05.016.
  Yan Jinpei, Yang Linjun, Shen Xianglin. Wettability of PM2.5 from combustion[J]. Journal of Southeast University(Natural Science Edition), 2006, 36(5): 760-764. DOI:10.3321/j.issn:1001-0505.2006.05.016.(in Chinese)
[13] 鲍静静.应用蒸汽相变促进WFGD系统脱除细颗粒物的研究[D].南京:东南大学能源与环境学院,2012.
[14] Bao J J, Yang L J, Guo W W, et al. Improving the removal of fine particles in the WFGD system by adding wetting agents[J]. Energy & Fuels, 2012, 26(8): 4924-4931. DOI:10.1021/ef3007195.
[15] 徐俊超,于燕,张军,等.生物质燃烧源PM2.5在水汽条件下长大的特性研究[J].燃料化学学报,2016,44(4):507-512. DOI:10.3969/j.issn.0253-2409.2016.04.018.
  Xu Junchao, Yu Yan, Zhang Jun, et al. Growth characteristics of biomass-fired PM2.5 with vapor condensation [J]. Journal of Fuel Chemistry and Technology, 2016, 44(4): 507-512. DOI:10.3969/j.issn.0253-2409.2016.04.018.(in Chinese)
[16] Chen C C, Hung L C, Hsu H K. Heterogeneous nucleation of water vapor on particles of SiO2, Al2O3, TiO2, and carbon black[J]. Journal of Colloid and Interface Science, 1993, 157(2): 465-477. DOI:10.1006/jcis.1993.1209.
[17] 颜金培,杨林军,凡凤仙.基于分形理论的水汽在燃煤细颗粒表面异质核化数值研究[J].中国电机工程学报,2009,29(11):50-56.
  Yan Jinpei, Yang Linjun, Fan Fengxian, et al. Numerical analysis of water vapor nucleation on fine particles from coal combustion based on fractal model[J]. Proceedings of the CSEE, 2009, 29(11): 50-56.(in Chinese)
[18] 周璐璐,张军,徐俊超,等.典型煤灰成分细颗粒物在过饱和水汽环境中的长大特性[J].燃料化学学报,2015,43(6):754-760. DOI:10.3969/j.issn.0253-2409.2015.06.017.
  Zhou Lulu, Zhang Jun, Xu Junchao, et al. Growth of fine particles of typical coal ash components in supersaturated water environment[J]. Journal of Fuel Chemistry and Technology, 2015, 43(6): 754-760. DOI:10.3969/j.issn.0253-2409.2015.06.017.(in Chinese)
[19] 肖衍繁,李文斌.物理化学[M].2版.天津:天津大学出版社,2004:484.
[20] Lathem T L, Nenes A. Water vapor depletion in the DMT continuous-flow CCN chamber: Effects on supersaturation and droplet growth[J]. Aerosol Science and Technology, 2011, 45(5): 604-615. DOI:10.1080/02786826.2010.551146.

相似文献/References:

[1]陆勇,赵长遂,姚伟文,等.凹型布风板流化床气、固动力特性试验—扬析[J].东南大学学报(自然科学版),1986,16(3):65.[doi:10.3969/j.issn.1001-0505.1986.03.007]
 Lu Yong,Zhao Changsui,Yao Weiwen,et al.Gas-Solid Kinetic Characteristics in Fluidized Bed with a Concave Distributor-Elutriation[J].Journal of Southeast University (Natural Science Edition),1986,16(1):65.[doi:10.3969/j.issn.1001-0505.1986.03.007]
[2]鲍静静,杨林军,颜金培,等.湿法脱硫系统中应用蒸汽相变技术脱除细颗粒[J].东南大学学报(自然科学版),2009,39(5):1002.[doi:10.3969/j.issn.1001-0505.2009.05.027]
 Bao Jingjing,Yang Linjun,Yan Jinpei,et al.Removal of fine particles in wet flue gas desulphurization system by heterogeneous condensation[J].Journal of Southeast University (Natural Science Edition),2009,39(1):1002.[doi:10.3969/j.issn.1001-0505.2009.05.027]

备注/Memo

备注/Memo:
收稿日期: 2016-06-22.
作者简介: 徐俊超(1990—),男,博士生;张军(联系人),男,博士,教授,博士生导师,junzhang@seu.edu.cn.
基金项目: 国家自然科学基金资助项目(51576043)、国家重点基础研究发展计划(973计划)资助项目(2013CB228504)、东南大学优秀博士学位论文培育基金资助项目(YBJJ1607)、江苏省普通高校研究生科研创新计划资助项目(KYLX16_0202).
引用本文: 徐俊超,于燕,张军,等.润湿剂促进细颗粒在水汽条件下长大的实验研究[J].东南大学学报(自然科学版),2017,47(1):67-72. DOI:10.3969/j.issn.1001-0505.2017.01.013.
更新日期/Last Update: 2017-01-20