[1]马涛,张道义,黄晓明.SBS改性沥青抽提回收影响因素及改进方案[J].东南大学学报(自然科学版),2008,38(5):811-815.[doi:10.3969/j.issn.1001-0505.2008.05.014]
　Ma Tao,Zhang Daoyi,Huang Xiaoming.Influential factors and improvement of extraction and recovery of SBS modified asphalt[J].Journal of Southeast University (Natural Science Edition),2008,38(5):811-815.[doi:10.3969/j.issn.1001-0505.2008.05.014]
点击复制

SBS改性沥青抽提回收影响因素及改进方案()
分享到：

《东南大学学报(自然科学版)》[ISSN:1001-0505/CN:32-1178/N]

卷:
38
期数:
2008年第5期
页码:
811-815
栏目:
交通运输工程
出版日期:
2008-09-20

文章信息/Info

Title:
Influential factors and improvement of extraction and recovery of SBS modified asphalt
作者:
马涛;  张道义;  黄晓明
东南大学交通学院, 南京 210096
Author(s):
Ma Tao;  Zhang Daoyi;  Huang Xiaoming
School of Transportation, Southeast University,Nanjing 210096, China
关键词:
道路工程;  试验验证;  抽提回收;  改性沥青;  三氯乙烯;  矿粉
Keywords:
road engineering;  experimental validation;  extraction and recovery;  SBS(styrene-butadience-styrene copolymer)modified asphalt;  trichloroethylene;  mineral filler
分类号:
U416.03
DOI:
10.3969/j.issn.1001-0505.2008.05.014
摘要:
分析国内目前使用最广泛的离心抽提法和阿布森回收法的不足及其产生原因.针对SBS改性沥青的抽提回收,设计不同的对比试验,研究三氯乙烯、矿粉及温度等关键影响因素对回收SBS改性沥青性能的影响程度与规律.在现有试验方法的基础上,针对其不足之处以及不同的影响因素,制定相应的补充改进措施:针对矿粉的干扰,当不具备高速离心分离及压力过滤设备时,通过将抽提所得混合液自然沉淀24 h以上,然后取上层混合溶液进行回收试验,以消除矿粉影响; 针对三氯乙烯的影响,调整阿布森试验温度不高于140 ℃,可以不使用保护气,直至不再有冷凝的三氯乙烯产生时,取出混合液并置于宽口径容器中,在烘箱内130～140 ℃搅拌蒸发2 h,然后调整温度至160～170 ℃继续搅拌蒸发2 h,以消除三氯乙烯的影响.从而提高试验精度,准确评价抽提回收SBS改性沥青性能.
Abstract:
The centrifugal extraction method and Abson recovery method are most commonly used at home and abroad in recent years. The defects and corresponding possible reasons for these two methods are analyzed. Considering the characters of SBS(styrene-butadience-styrene copolymer)modified asphalt mixtures, several different tests were designed and carried out to verify influences of some key factors such as trichloroethylene, mineral filler, temperature on the reclaimed SBS modified asphalt during the process of extraction and recovery experiments. And the corresponding solutions for different influencing factors were presented so that the performances of SBS modified asphalt in SBS modified asphalt mixture can be evaluated accurately. To decrease the adverse effects from residual mineral filler, when there are no equipments for high-speed centrifugal separation and pressure filtration, the upper part of the extracting solution from the extraction equipment is adopted for Abson recovery experiment after natural sediment for more than 24 hours. To decrease the adverse effects from residual trichloroethylene and high temperature, the temperature of Abson recovery experiment can be reduced to less than 140 ℃,and the protection gas can be removed, when there is no condensing liquid trichloroethylene coming out from the end orifice of the condenser tube, the solution in the Abson flask can be poured into a vessel with wider caliber to be evaporated with incessant churning for 2 hours at the temperature of 130 to 140 ℃, and then evaporated with incessant churning for another 2 hours at the temperature of 160 to 170 ℃ in the oven.

参考文献/References:

[1] 中华人民共和国交通部.JTJ 052—2000 公路工程沥青及沥青混合料试验规程[S].北京:人民交通出版社,2000.
[2] 黄晓明,赵永利,江臣.沥青路面再生利用试验分析[J].岩土工程学报,2001,23(4):468-471.
　 Huang Xiaoming,Zhao Yongli,Jiang Chen.Test and analysis of recycled mixture for old asphalt pavement[J]. Chinese Journal of Geotechnical Engineering,2001,23(4):468-471.(in Chinese)
[3] Stroup-Gardiner M,Nelson J W.Use of normal propyl bromide solvents for extraction and recovery of asphalt cements[R].Auburn,USA:Auburn University Press,2000.
[4] Carey D E,Paul M R.Evaluation of asphalt cement extraction and recovery methods[R].Washtington DC:Federal Highway Administration,1982.
[5] Abson G.Method and apparatus for the recovery of asphalt[R].New York:American Society for Testing and Materials Press,1933.
[6] Abson G,Burton C.The use of chlorinated solvents in the Abson recovery method [J].Proceedings Association of Asphalt Paving Technologists,1960,29(3):99-213.
[7] 沈金安.改性沥青与SMA路面 [M].北京:人民交通出版社,1999.
[8] McDaniel R S,Soleymani H,Anderson R M,et al.Recommended use of reclaimed asphalt pavement in the superpave mix design method[R].Washington DC:National Academy Press,2001.

相似文献/References:

[1]魏建军,邢姣秀,付智.行车荷载引起桥梁振动对修复混凝土性能影响[J].东南大学学报(自然科学版),2010,40(5):1057.[doi:10.3969/j.issn.1001-0505.2010.05.033]
　Wei Jianjun,Xing Jiaoxiu,Fu Zhi.Effect of traffic load induced bridge vibrations on concrete tensile properties[J].Journal of Southeast University (Natural Science Edition),2010,40(5):1057.[doi:10.3969/j.issn.1001-0505.2010.05.033]
[2]倪富健,成晟,顾兴宇,等.路面结构的动态谱元分析[J].东南大学学报(自然科学版),2010,40(3):575.[doi:10.3969/j.issn.1001-0505.2010.03.027]
　Ni Fujian,Cheng Sheng,Gu Xingyu,et al.Spectral element analysis of dynamic pavement structure response[J].Journal of Southeast University (Natural Science Edition),2010,40(5):575.[doi:10.3969/j.issn.1001-0505.2010.03.027]
[3]黄宝涛,廖公云,张静芳.半刚性基层沥青路面层间接触临界状态值的计算方法[J].东南大学学报(自然科学版),2007,37(4):666.[doi:10.3969/j.issn.1001-0505.2007.04.024]
　Huang Baotao,Liao Gongyun,Zhang Jingfang.Analytical method of interlayer contact fettle in semi-rigid-base bituminous pavement[J].Journal of Southeast University (Natural Science Edition),2007,37(5):666.[doi:10.3969/j.issn.1001-0505.2007.04.024]
[4]陈俊,黄晓明.采用离散元方法评价集料的骨架结构[J].东南大学学报(自然科学版),2012,42(4):761.[doi:10.3969/j.issn.1001-0505.2012.04.035]
　Chen Jun,Huang Xiaoming.Evaluation of aggregate skeleton structure using the discrete element method[J].Journal of Southeast University (Natural Science Edition),2012,42(5):761.[doi:10.3969/j.issn.1001-0505.2012.04.035]
[5]孙志林,黄晓明.沥青路面线性疲劳损伤特性及形变规律[J].东南大学学报(自然科学版),2012,42(3):521.[doi:10.3969/j.issn.1001-0505.2012.03.025]
　Sun Zhilin,Huang Xiaoming.Linear fatigue damage characteristics and deformation law of asphalt pavement[J].Journal of Southeast University (Natural Science Edition),2012,42(5):521.[doi:10.3969/j.issn.1001-0505.2012.03.025]
[6]王艳,倪富健,李再新.水泥稳定碎石基层温缩性能试验及预估控制[J].东南大学学报(自然科学版),2008,38(2):260.[doi:10.3969/j.issn.1001-0505.2008.02.015]
　Wang Yan,Ni Fujian,Li Zaixin.Test and estimate control on temperature shrinkage performance of cement-treated macadam[J].Journal of Southeast University (Natural Science Edition),2008,38(5):260.[doi:10.3969/j.issn.1001-0505.2008.02.015]
[7]李志栋,黄晓明,岳学军.半刚性基层沥青路面非连续结构强迫振动声效[J].东南大学学报(自然科学版),2011,41(6):1277.[doi:10.3969/j.issn.1001-0505.2011.06.028]
　Li Zhidong,Huang Xiaoming,Yue Xuejun.Sound analysis of forced vibration feature of discontinuous structure in semi-rigid base asphalt pavement[J].Journal of Southeast University (Natural Science Edition),2011,41(5):1277.[doi:10.3969/j.issn.1001-0505.2011.06.028]
[8]孙璐,辛宪涛,任皎龙.纳米改性沥青混合料路用性能[J].东南大学学报(自然科学版),2013,43(4):873.[doi:10.3969/j.issn.1001-0505.2013.04.037]
　Sun Lu,Xin Xiantao,Ren Jiaolong.Pavement performance of nanomaterial modified asphalt mixture[J].Journal of Southeast University (Natural Science Edition),2013,43(5):873.[doi:10.3969/j.issn.1001-0505.2013.04.037]
[9]陈俊,黄晓明.路面加铺后旧沥青混合料的疲劳性能[J].东南大学学报(自然科学版),2008,38(3):516.[doi:10.3969/j.issn.1001-0505.2008.03.030]
　Chen Jun,Huang Xiaoming.Fatigue performance of old pavement asphalt mixtures after overlay[J].Journal of Southeast University (Natural Science Edition),2008,38(5):516.[doi:10.3969/j.issn.1001-0505.2008.03.030]
[10]汪海年,郝培文,肖庆一,等.粗集料棱角性的图像评价方法[J].东南大学学报(自然科学版),2008,38(4):637.[doi:10.3969/j.issn.1001-0505.2008.04.018]
　Wang Hainian,Hao Peiwen,Xiao Qingyi,et al.Digital image evaluation method for angularity of coarse aggregates[J].Journal of Southeast University (Natural Science Edition),2008,38(5):637.[doi:10.3969/j.issn.1001-0505.2008.04.018]

备注/Memo

备注/Memo:
作者简介: 马涛(1981—),男,博士生; 黄晓明(联系人),男,博士,教授,博士生导师,huangxm@seu.edu.cn.
基金项目: 国家高技术研究发展计划(863计划)资助项目(2006AA11Z110)、江苏省交通科技资助项目(06Y31).
引文格式: 马涛,张道义,黄晓明.SBS改性沥青抽提回收影响因素及改进方案[J].东南大学学报:自然科学版,2008,38(5):811-815.
更新日期/Last Update: 2008-09-20