[1]蔡建,袁慎芳,邱雷,等.基于波包能量的裂纹扩展监测实验研究[J].东南大学学报(自然科学版),2009,39(3):477-483.[doi:10.3969/j.issn.1001-0505.2009.03.012]
 Cai Jian,Yuan Shenfang,Qiu Lei,et al.Experimental study on crack growth monitoring based on wave packet energy[J].Journal of Southeast University (Natural Science Edition),2009,39(3):477-483.[doi:10.3969/j.issn.1001-0505.2009.03.012]
点击复制

基于波包能量的裂纹扩展监测实验研究()
分享到:

《东南大学学报(自然科学版)》[ISSN:1001-0505/CN:32-1178/N]

卷:
39
期数:
2009年第3期
页码:
477-483
栏目:
材料科学与工程
出版日期:
2009-05-20

文章信息/Info

Title:
Experimental study on crack growth monitoring based on wave packet energy
作者:
蔡建 袁慎芳 邱雷 张逍越 王瑜
南京航空航天大学智能材料与结构航空科技重点实验室, 南京 210016
Author(s):
Cai Jian Yuan Shenfang Qiu Lei Zhang Xiaoyue Wang Yu
The Aeronautic Key Laboratory of Smart Material and Structure, Nanjing University of Aeronautics and Astronautics,Nanjing 210016, China
关键词:
裂纹扩展 结构健康监测 Lamb波 波包能量 中心频率
Keywords:
crack growth structural health monitoring Lamb wave wave packet energy central frequency
分类号:
TB31;TB302.5
DOI:
10.3969/j.issn.1001-0505.2009.03.012
摘要:
采用主动Lamb波监测技术对铝板结构中的疲劳裂纹扩展进行了实验研究.首先通过布置在结构中的压电片激发并采集Lamb波信号.然后分别把Lamb波信号的原始信号、信号包络及其特定尺度上的小波系数模值定义为波包,并建立了不同定义下波包能量的计算公式.将结构在裂纹扩展过程中传感器所接收的Lamb波S0模式波包能量与健康状态下所得到的波包能量进行对比,得到每个裂纹扩展阶段的能量差,将其归一化后得到相应的裂纹损伤特征参数.最后通过实验分析得到该损伤特征参数与裂纹扩展程度之间的对应关系,从而揭示出Lamb波随裂纹扩展的变化规律.实验结果表明,利用上述方法所得到的裂纹损伤特征参数随裂纹扩展表现出特定的变化规律.该规律对于裂纹监测的进一步研究具有促进作用.
Abstract:
Active Lamb wave diagnostic technology is adopted to monitor fatigue crack growth in the experimental study. First, a Lamb wave signal is generated and collected by piezoelectric(PZT)wafers embedded in an aluminium plate. With wave packet defined as original signal, signal envelope and modules of wavelet coefficients at a specific scale respectively, the calculation formula of its energy is then established. The normalized difference between the wave packet energy of S0 mode of the Lamb wave received when a crack grows and the energy in the initial state is determined as a crack damage index. Finally, experiments are designed to research the relationships between the damage index and the real crack growth. Experimental results show that the damage index increases with the crack growth in a certain rule. This rule can promote the crack monitoring research.

参考文献/References:

[1] Ihn J B,Chang F K.Detection and monitoring of hidden fatigue crack growth using a built-in piezoelectric sensor/actuator network:Ⅰ.diagnostics[J]. Smart Materials and Structures,2004,13(3):609-620.
[2] Giurgiutiu V,Jenkins C,Kendall J,et al.In-situ imaging of crack growth with piezoelectric wafer active sensors[J]. AIAA Journal,2007,45(11):2758-2769.
[3] Giurgiutiu V,Xu B,Chao Y,et al.Smart sensors for monitoring crack growth under fatigue loading conditions[J]. Smart Structures and Systems,2006,2(2):1-18.
[4] Giurgiutiu V,Rogers Craig A.Recent advancements in the electro-mechanical(E/M)impedance method for structural health monitoring and NDE[C] //Smart Structures and Integrated Systems.San Diego,USA,1998:536-547.
[5] Giurgiutiu V,Zagrai A,Bao J.Embedded active sensors for in-situ structural health monitoring of thin-wall structures[J]. Journal of Pressure Vessel Technology,2002,124(3):293-302.
[6] Giurgiutiu V,Cuc A.Embedded non-destructive evaluation for structural health monitoring,damage detection,and failure prevention[J].The Shock and Vibration Digest,2005,37(2):83-105.
[7] 张凤林,韩维,胡国才,等.声发射技术在航空领域的应用研究[J].无损检测,2000,22(4):157-161.
  Zhang Fenglin,Han Wei,Hu Guocai,et al.Research on the application of AE in the field of aviation[J].Nondestructive Testing,2000,22(4):157-161.(in Chinese)
[8] 李光海,刘正义.基于声发射技术的金属高频疲劳监测[J].中国机械工程,2004,15(13):1205-1209.
  Li Guanghai,Liu Zhengyi.Inspection of metal high frequency cyclic fatigue behavior utilizing acoustic emission technique[J]. China Mechanical Engineering,2004,15(13):1205-1209.(in Chinese)
[9] 刘涛,李爱群,丁幼亮.基于小波包能量谱的大跨斜拉桥拉索损伤预警方法[J].东南大学学报:自然科学版,2007,37(2):270-274.
  Liu Tao,Li Aiqun,Ding Youliang.Alarming method for cable damage of long-span cable-stayed bridges based on wavelet packet energy spectrum[J].Journal of Southeast University:Natural Science Edition,2007,37(2):270-274.(in Chinese)
[10] 何振宇,张森文.基于小波包频带能量检测技术的结构损伤诊断[J].暨南大学学报:自然科学版,2007,28(5):431-434.
  He Zhenyu,Zhang Senwen.Damage diagnosis of structure based on wavelet packet frequency band energy detecting technology[J]. Journal of Jinan University:Natural Science,2007,28(5):431-434.(in Chinese)
[11] 师小红,徐章遂,敦怡,等.基于“能量比较法”的金属基复合材料缺陷信号特征提取[J].煤矿机械,2006,27(6):1094-1096.
  Shi Xiaohong,Xu Zhangsui,Dun Yi,et al.Extraction of defect features of metal matrix composite based on“energy-comparison”[J].Coal Mine Machinery,2006,27(6):1094-1096.(in Chinese)
[12] 彭鸽,袁慎芳,徐颖娣.基于主动Lamb波和小波变换的二维结构损伤定位研究[J].振动工程学报,2004,17(4):488-493.
  Peng Ge,Yuan Shenfang,Xu Yingdi.Damage location of two-dimensional structure based on wavelet transform and active monitoring technology of Lamb wave[J].Journal of Vibration Engineering,2004,17(4):488-493.(in Chinese)
[13] 袁慎芳.结构健康监控[M].北京:国防工业出版社,2007:205-208.

相似文献/References:

[1]李爱群,周广东.光纤Bragg光栅传感器测试技术研究进展与展望(Ⅰ):应变、温度测试[J].东南大学学报(自然科学版),2009,39(6):1298.[doi:10.3969/j.issn.1001-0505.2009.06.041]
 Li Aiqun,Zhou Guangdong.Progress and prospect of fiber Bragg grating sensors measurement technology(Ⅰ): strain and temperature measurement[J].Journal of Southeast University (Natural Science Edition),2009,39(3):1298.[doi:10.3969/j.issn.1001-0505.2009.06.041]
[2]李爱群,丁幼亮,费庆国,等.润扬大桥斜拉桥模态频率识别的环境变异性[J].东南大学学报(自然科学版),2007,37(2):245.[doi:10.3969/j.issn.1001-0505.2007.02.013]
 Li Aiqun,Ding Youliang,Fei Qingguo,et al.Environmental variability in modal frequency identification of Runyang Cable-Stayed Bridge[J].Journal of Southeast University (Natural Science Edition),2007,37(3):245.[doi:10.3969/j.issn.1001-0505.2007.02.013]
[3]黄盛楠,叶列平,陆新征,等.CFRP预警传感器的研究[J].东南大学学报(自然科学版),2006,36(5):810.[doi:10.3969/j.issn.1001-0505.2006.05.026]
 Huang Shengnan,Ye Lieping,Lu Xinzheng,et al.Research on CFRP alarm sensors[J].Journal of Southeast University (Natural Science Edition),2006,36(3):810.[doi:10.3969/j.issn.1001-0505.2006.05.026]
[4]缪长青,李爱群.异形钢管混凝土系杆拱桥结构健康监测系统[J].东南大学学报(自然科学版),2011,41(6):1241.[doi:10.3969/j.issn.1001-0505.2011.06.022]
 Miao Changqing,Li Aiqun.Structural health monitoring system for special-shaped concrete-filled steel tubular arch bridge[J].Journal of Southeast University (Natural Science Edition),2011,41(3):1241.[doi:10.3969/j.issn.1001-0505.2011.06.022]
[5]李爱群,周广东.光纤Bragg光栅传感器测试技术研究进展与展望(Ⅱ):位移、加速度、索力、钢筋锈蚀、裂缝测试[J].东南大学学报(自然科学版),2009,39(6):1307.[doi:10.3969/j.issn.1001-0505.2009.06.042]
 Li Aiqun,Zhou Guangdong.Progress and prospect of fiber Bragg grating sensors measurement technology(Ⅱ): displacement, acceleration, cable force, corrosion, and crack measurement[J].Journal of Southeast University (Natural Science Edition),2009,39(3):1307.[doi:10.3969/j.issn.1001-0505.2009.06.042]
[6]邓扬,李爱群,丁幼亮.基于最大熵理论的润扬悬索桥桥址极值风速预测[J].东南大学学报(自然科学版),2008,38(5):758.[doi:10.3969/j.issn.1001-0505.2008.05.004]
 Deng Yang,Li Aiqun,Ding Youliang.Prediction of extreme wind speed for Runyang Suspension Bridge spot based on maximum entropy theory[J].Journal of Southeast University (Natural Science Edition),2008,38(3):758.[doi:10.3969/j.issn.1001-0505.2008.05.004]
[7]李兆霞.大型土木结构多尺度损伤预后的现状、研究思路与前景[J].东南大学学报(自然科学版),2013,43(5):1111.[doi:10.3969/j.issn.1001-0505.2013.05.034]
 Li Zhaoxia.State of the art in multi-scale damage prognosis for major infrastructures[J].Journal of Southeast University (Natural Science Edition),2013,43(3):1111.[doi:10.3969/j.issn.1001-0505.2013.05.034]
[8]黄兴淮,徐赵东,Dyke Shirley.基于能量原理和Kalman滤波器的实时模型修正策略[J].东南大学学报(自然科学版),2015,45(3):539.[doi:10.3969/j.issn.1001-0505.2015.03.022]
 Huang Xinghuai,Xu Zhaodong,Dyke Shirley.In-time model updating strategy based on energy theory and Kalman filter[J].Journal of Southeast University (Natural Science Edition),2015,45(3):539.[doi:10.3969/j.issn.1001-0505.2015.03.022]
[9]黄其欢,丁幼亮,王一安,等.基于InSAR的南京大胜关大桥纵向位移监测与分析[J].东南大学学报(自然科学版),2017,47(3):584.[doi:10.3969/j.issn.1001-0505.2017.03.028]
 Huang Qihuan,Ding Youliang,Wang Yian,et al.InSAR-based longitudinal displacement monitoring and analysis on Nanjing Dashengguan bridge[J].Journal of Southeast University (Natural Science Edition),2017,47(3):584.[doi:10.3969/j.issn.1001-0505.2017.03.028]
[10]郑文智,王浩,杜永峰,等.环境激励下基础隔震结构时变模态频率的温度效应[J].东南大学学报(自然科学版),2017,47(5):999.[doi:10.3969/j.issn.1001-0505.2017.05.025]
 Zheng Wenzhi,Wang Hao,Du Yongfeng,et al.Temperature effect of time-varying modal frequency of base-isolated structure under ambient excitation[J].Journal of Southeast University (Natural Science Edition),2017,47(3):999.[doi:10.3969/j.issn.1001-0505.2017.05.025]

备注/Memo

备注/Memo:
作者简介: 蔡建(1982—),男,博士生; 袁慎芳(联系人),女,博士,教授,博士生导师,ysf@nuaa.edu.cn.
基金项目: 国家自然科学基金资助项目(60772072)、国家自然科学基金重点资助项目(50830201)、国家高技术研究发展计划(863计划)资助项目(2007AA03Z117).
引文格式: 蔡建,袁慎芳,邱雷,等.基于波包能量的裂纹扩展监测实验研究[J].东南大学学报:自然科学版,2009,39(3):477-483. [doi:10.3969/j.issn.1001-0505.2009.03.012]
更新日期/Last Update: 2009-05-20