[1]居静,钟文琪,李颖,等.旋转喷雾塔Ca(OH)2/NaClO2联合脱硫脱硝数值模拟[J].东南大学学报(自然科学版),2014,44(5):968-974.[doi:10.3969/j.issn.1001-0505.2014.05.017]
 Ju Jing,Zhong Wenqi,Li Ying,et al.Numerical simulation of simultaneous desulfurization and denitration using Ca(OH)2/NaClO2 in rotary spray tower[J].Journal of Southeast University (Natural Science Edition),2014,44(5):968-974.[doi:10.3969/j.issn.1001-0505.2014.05.017]
点击复制

旋转喷雾塔Ca(OH)2/NaClO2联合脱硫脱硝数值模拟()
分享到:

《东南大学学报(自然科学版)》[ISSN:1001-0505/CN:32-1178/N]

卷:
44
期数:
2014年第5期
页码:
968-974
栏目:
环境科学与工程
出版日期:
2014-09-20

文章信息/Info

Title:
Numerical simulation of simultaneous desulfurization and denitration using Ca(OH)2/NaClO2 in rotary spray tower
作者:
居静1钟文琪1李颖1周颖倩1王天才2刘飞2
1东南大学能源热转换及其过程测控教育部重点实验室, 南京 210096; 2南京钢铁股份有限公司, 南京 210035
Author(s):
Ju Jing1 Zhong Wenqi1 Li Ying1 Zhou Yingqian1 Wang Tiancai2 Liu Fei2
1Key Laboratory of Energy Thermal Conversion and Control of Ministry of Education, Southeast University, Nanjing 210096, China
2Nanjing Iron and Steel Co., Ltd., Nanjing 210035, China
关键词:
脱硫脱硝 旋转喷雾塔 数值模拟 欧拉-拉格朗日方法 脱除效率
Keywords:
desulfurization and denitration rotating spray tower numerical simulation Euler-Lagrange approach removal efficiency
分类号:
X75
DOI:
10.3969/j.issn.1001-0505.2014.05.017
摘要:
针对开发低温烟气联合脱硫脱硝技术的需求,采用欧拉-拉格朗日方法,建立了旋转喷雾塔气固流动与脱硫脱硝反应耦合的三维数理模型.气相场采用k-ε湍流模型,SO2,NOxx的吸收采用双膜理论模型.以2个180m2烧结烟气的旋转喷雾塔为模拟对象,采用Ca(OH)2/NaClO2浆液作为吸收剂,考察了NaClO2/Ca(OH)2摩尔比、烟气流速、烟气温度、SO2和NO的浓度等对烟气二氧化硫和氮氧化物脱除效率的影响.研究结果表明:随着溶液中NaClO2/Ca(OH)2摩尔比的增加,氮氧化物的脱除效率显著提高,二氧化硫的脱除效率无明显变化;随烟气流速、温度的增大,二氧化硫以及氮氧化物脱除效率均有所降低;氮氧化物的脱除效率随SO2浓度的增大无显著变化,而二氧化硫的脱除效率明显降低;随NO浓度的增加,氮氧化物脱除效率明显降低,二氧化硫脱除效率无显著变化.
Abstract:
A three-dimensional numerical model of a rotating spray tower gas-solid flow coupling with simultaneous desulfurization and denitration reaction was set up on the Euler-Lagrange approach for the demand of the development of low temperature flue gas desulfurization and denitration technology. The k-ε turbulence model was used for the gas phase, and the two-film theory absorption model for the absorption of SO2, NOxx. The investigation of the influence of NaClO2/Ca(OH)2 molar ratio, gas velocity, gas temperature, SO2 and NO concentration on the removal efficiency of sulfur dioxide and nitrogen oxides using Ca(OH)2/NaClO2 slurry as the absorbent was carried out on a model of 2×180 m2 sintering gas rotating spray tower. Research results show that with the increase of NaClO2/Ca(OH)2 molar ratio, the removal efficiency of nitrogen oxides increases significantly, while the removal efficiency of sulfur dioxide has no obvious change. With the increase of gas velocity and temperature, both the removal efficiency of sulfur dioxide and nitrogen oxides decrease. The removal efficiency of nitrogen oxides has no significant change with the increase of SO2 concentration, while the removal efficiency of sulfur dioxide decreases obviously. With the increase of NO concentration, the removal efficiency of nitrogen oxides decreases obviously, while the removal efficiency of sulfur dioxide has no significant change.

参考文献/References:

[1] 李虎,曾毅夫,周益辉,等. 低温条件下烟气脱硫脱硝技术的研究与应用[J]. 中国环保产业,2014(1): 11-14.
  Li Hu, Zeng Yifu, Zhou Yihui, et al. Research and application on FGD and denitration technologies under low temperature condition[J]. China Environmental Protection Industry, 2014(1): 11-14.(in Chinese)
[2] Sun Weiyi, Ding Sanglan, Zeng Shanshan, et al. Simultaneous absorption of NOxx and SO2 from flue gas with pyrolusite slurry combined with gas-phase oxidation of NO using ozone[J]. Journal of Hazardous Materials, 2011, 192(1): 124-130.
[3] Ding Jie, Zhong Qin, Zhang Shule, et al. Simultaneous removal of NOxx and SO2 from coal-fired flue gas by catalytic oxidation-removal process with H2O2[J]. Chemical Engineering Journal, 2014, 243: 176-182.
[4] Zhao Yi, Guo Tianxiang, Chen Zhouyan, et al. Simultaneous removal of SO2 and NO using M/NaClO2 complex absorbent[J]. Chemical Engineering Journal, 2010, 160(1): 42-47.
[5] 王乃华,滕斌,高翔,等. 半干法烟气脱硫整体化模型[J]. 动力工程, 2008, 28(5): 774-778,788.
  Wang Naihua, Teng Bin, Gao Xiang, et al. Integrated modeling of semi-dry flue gas desulfurization[J]. Journal of Power Engineering, 2008, 28(5): 774-778, 788.(in Chinese)
[6] Newton G H, Kramlich J, Payne R. Modeling the SO2-slurry droplet reaction[J]. AIChE Journal, 1990, 36(12): 1865-1872.
[7] Chien T W, Chu H, Hsueh H T. Kinetic study on absorption of SO2 and NO with acidic NaClO2 solutions using the spraying column[J]. Journal of Environmental Engineering, 2003, 129(11): 967-974.
[8] Deshwal B R, Jin D S, Lee S H, et al. Removal of NO from flue gas by aqueous chlorine-dioxide scrubbing solution in a lab-scale bubbling reactor[J]. Journal of Hazardous Materials, 2008, 150(3): 649-655.
[9] Deshwal B R,Lee S H, Jung J H, et al. Study on the removal of NOxx from simulated flue gas using acidic NaClO2 solution[J]. Journal of Environmental Sciences, 2008, 20(1): 33-38.
[10] Treamoto M, Ikeda M, Teranishi H. Absorption rates of NO in mixed aqueous solution of NaClO2 and NaOH[J]. Kagaku Kogaku Ronbunshu, 1976(2): 637-640.
[11] Sada E, Kumazawa H, Kudo I, et al. Absorption of lean NOxx in aqueous solutions of NaClO2 and NaOH[J]. Industrial & Engineering Chemistry Process Design and Development, 1979(18): 275-278.
[12] Sada E, Kumazawa H, Yamanka Y, et al. Absorption of lean NO in aqueous slurries of Ca(OH)2 with NaClO2 or Mg(OH)2 with NaClO2[J]. Chemical Engineering Science, 1979, 34: 719-724.

备注/Memo

备注/Memo:
收稿日期: 2014-05-07.
作者简介: 居静(1990—),女,硕士生;钟文琪(联系人),男,博士,教授,博士生导师,wqzhong@seu.edu.cn.
基金项目: 国家杰出青年科学基金资助项目(51325601)、国家自然科学基金重大资助项目(51390492)、英国工程和物理科学研究委员会国际合作资助项目(EP/G063176/1).
引用本文: 居静, 钟文琪, 李颖,等.旋转喷雾塔Ca(OH)2/NaClO2联合脱硫脱硝数值模拟[J].东南大学学报:自然科学版,2014,44(5):968-974. [doi:10.3969/j.issn.1001-0505.2014.05.017]
更新日期/Last Update: 2014-09-20