[1]刘新,吴淼,施锦杰.耐蚀钢筋在混凝土模拟液中的电化学行为[J].东南大学学报(自然科学版),2019,49(3):502-506.[doi:10.3969/j.issn.1001-0505.2019.03.014]
 Liu Xin,Wu Miao,Shi Jinjie.Electrochemical behavior of corrosion-resistant rebar in simulated concrete pore solutions[J].Journal of Southeast University (Natural Science Edition),2019,49(3):502-506.[doi:10.3969/j.issn.1001-0505.2019.03.014]
点击复制

耐蚀钢筋在混凝土模拟液中的电化学行为()
分享到:

《东南大学学报(自然科学版)》[ISSN:1001-0505/CN:32-1178/N]

卷:
49
期数:
2019年第3期
页码:
502-506
栏目:
材料科学与工程
出版日期:
2019-05-20

文章信息/Info

Title:
Electrochemical behavior of corrosion-resistant rebar in simulated concrete pore solutions
作者:
刘新1吴淼1施锦杰12
1东南大学材料科学与工程学院, 南京 211189; 2江苏省土木工程材料重点实验室, 南京 211189
Author(s):
Liu Xin1 Wu Miao1 Shi Jinjie12
1School of Materials Science and Engineering, Southeast University, Nanjing 211189, China
2Jiangsu Key Laboratory of Construction Materials, Southeast University, Nanjing 211189, China
关键词:
耐蚀钢筋 电化学阻抗谱 碳化与氯盐耦合 腐蚀产物
Keywords:
corrosion-resistant rebar electrochemical impedance spectroscopy simultaneous carbonation and chloride attacking corrosion products
分类号:
TG172
DOI:
10.3969/j.issn.1001-0505.2019.03.014
摘要:
利用电化学阻抗谱法(EIS)对比研究了新型耐蚀钢筋(00Cr10MoV)和普通低碳钢筋(20MnSiV)在混凝土模拟液中的自钝化、碳化以及碳化与氯盐耦合作用下的电化学行为,并利用扫描电镜(SEM)观察了钢筋表面腐蚀产物的形貌.结果表明,00Cr10MoV钢筋在钝化期的致钝性明显优于20MnSiV钢筋,且在碳化、碳化与氯盐耦合作用下,00Cr10MoV钢筋的耐蚀性也更强.电化学参数拟合中,00Cr10MoV钢筋在碳化期的钝化膜电阻和电荷转移电阻分别约为20MnSiV钢筋的3倍和58倍;00Cr10MoV钢筋在碳化和氯盐耦合作用期的钝化膜电阻和电荷转移电阻相比于20MnSiV钢筋分别提高约89%和99%.碳化与氯盐耦合作用后,00Cr10MoV钢筋表面仅生成少量点蚀坑,而20MnSiV钢筋表面则出现大量疏松的腐蚀产物.
Abstract:
Electrochemical impedance spectroscopy(EIS)was used to compare the electrochemical behaviors of the corrosion-resistant rebar(00Cr10MoV)and the ordinary low-carbon rebar(20MnSiV)in simulated concrete pore solutions on spontaneous passivation, carbonation, and simultaneous carbonation and chloride attack. Moreover, scanning electron microscopy(SEM)was used to observe the morphology of corrosion products on the surface of rebars. The results show that the passivation capacity of 00Cr10MoV rebar is much better than that of 20MnSiV rebar, and the corrosion resistance of 00Cr10MoV rebar subjected to carbonation and simultaneous carbonation and chlorides attack is also higher compared with that of 20MnSiV rebar. In the electrochemical parameter fitting, the passivation film resistance and charge transfer resistance of 00Cr10MoV rebar in the carbonation period are about 3 times and 58 times that of 20MnSiV rebar, respectively; Compared with the 20MnSiV rebar, the passivation film resistance and charge transfer resistance of 00Cr10MoV rebar in the simultaneous carbonation and chloride attacking period increase by 89% and 99%, respectively. After simultaneous carbonation and chlorides attacking, only a small amount of corrosion pits are found on the surface of 00Cr10MoV rebar, however, a large amount of loose corrosion products are observed on the surface of 20MnSiV rebar.

参考文献/References:

[1] Shi X M, Xie N, Fortune K, et al. Durability of steel reinforced concrete in chloride environments: An overview[J]. Construction and Building Materials, 2012, 30: 125-138. DOI:10.1016/j.conbuildmat.2011.12.038.
[2] Serdar M, ?ulj L V, Bjegovié D. Long-term corrosion behaviour of stainless reinforcing steel in mortar exposed to chloride environment[J].Corrosion Science, 2013, 69: 149-157. DOI:10.1016/j.corsci.2012.11.035.
[3] Hurley M F, Scully J R. Threshold chloride concentrations of selected corrosion-resistant rebar materials compared to carbon steel[J]. Corrosion, 2006, 62(10): 892-904. DOI:10.5006/1.3279899.
[4] Presuel-Moreno F, Scully J R, Sharp S R. Literature review of commercially available alloys that have potential as low-cost, corrosion-resistant concrete reinforcement[J].Corrosion, 2010, 66(8): 0860011-08600113. DOI:10.5006/1.3479955.
[5] Chen Y, Yang Z M, Wang H M. Comprehensive properties of 400 MPa grade corrosion-resistant rebar[J].Journal of Iron and Steel Research International, 2012, 19(12): 48-52. DOI:10.1016/s1006-706x(13)60031-x.
[6] 刘新, 王楚赫, 林云敏, 等. 新型00Cr10MoV钢筋在水泥萃取液中的耐氯离子点蚀性能[J]. 腐蚀与防护, 2018, 39(8): 623-628. DOI:10.11973/fsyfh-201808011.
Liu X, Wang C H, Lin Y M, et al. Pitting corrosion resistance to chloride of 00Cr10MoV rebar in cement extract solution[J]. Corrosion and Protection, 2018, 39(8): 623-628. DOI:10.11973/fsyfh-201808011. (in Chinese)
[7] 金柱, 程学群, 刘明, 等. Cr对耐蚀钢筋在混凝土模拟液中耐蚀机理的影响[J]. 腐蚀科学与防护技术, 2016, 28(4): 291-297.
  Jin Z, Cheng X Q, Liu M, et al. Influence of Cr on corrosion performance of corrosion-resistant rebar 5Cr steel in simulated concrete pore solutions[J]. Corrosion Science and Protection Technology, 2016, 28(4): 291-297.(in Chinese)
[8] Hakiki N E, Montemor M F, Ferreira M G S, et al. Semiconducting properties of thermally grown oxide films on AISI 304 stainless steel[J].Corrosion Science, 2000, 42(4): 687-702. DOI:10.1016/s0010-938x(99)00082-7.
[9] Luo H, Dong C F, Xiao K, et al. Characterization of passive film on 2205 duplex stainless steel in sodium thiosulphate solution[J].Applied Surface Science, 2011, 258(1): 631-639. DOI:10.1016/j.apsusc.2011.06.077.
[10] Freire L, Carmezim M J, Ferreira M G S, et al. The passive behaviour of AISI 316 in alkaline media and the effect of pH: A combined electrochemical and analytical study[J].Electrochimica Acta, 2010, 55(21): 6174-6181. DOI:10.1016/j.electacta.2009.10.026.
[11] Singh J K, Singh D D N. The nature of rusts and corrosion characteristics of low alloy and plain carbon steels in three kinds of concrete pore solution with salinity and different pH[J]. Corrosion Science, 2012, 56: 129-142. DOI:10.1016/j.corsci.2011.11.012.

相似文献/References:

[1]左晓宝,蒋慷,冯禹翔,等.模拟孔溶液中球墨铸铁表面钝化膜脱钝过程及氯离子阈值分析[J].东南大学学报(自然科学版),2017,47(2):392.[doi:10.3969/j.issn.1001-0505.2017.02.031]
 Zuo Xiaobao,Jiang Kang,Feng Yuxiang,et al.Analysis on depassivation process and chloride ion threshold of passive film on surface of ductile iron in simulated pore solution[J].Journal of Southeast University (Natural Science Edition),2017,47(3):392.[doi:10.3969/j.issn.1001-0505.2017.02.031]

备注/Memo

备注/Memo:
收稿日期: 2018-09-08.
作者简介: 刘新(1995—),男,博士生; 施锦杰(联系人),男,博士,副教授,jinjies@seu.edu.cn.
基金项目: 国家自然科学基金资助项目(51678144)、江苏省自然科学基金资助项目(BK20161420).
引用本文: 刘新,吴淼,施锦杰.耐蚀钢筋在混凝土模拟液中的电化学行为[J].东南大学学报(自然科学版),2019,49(3):502-506. DOI:10.3969/j.issn.1001-0505.2019.03.014.
更新日期/Last Update: 2019-05-20