[1]袁来运,钟文琪,陈曦,等.面向深度调峰的超临界煤粉锅炉变负荷燃烧三维数值模拟[J].东南大学学报(自然科学版),2019,49(3):535-541.[doi:10.3969/j.issn.1001-0505.2019.03.019]
 Yuan Laiyun,Zhong Wenqi,Chen Xi,et al.Three-dimensional numerical simulation of variable load combustion of supercritical coal-fired boiler for deep peak load regulation[J].Journal of Southeast University (Natural Science Edition),2019,49(3):535-541.[doi:10.3969/j.issn.1001-0505.2019.03.019]
点击复制

面向深度调峰的超临界煤粉锅炉变负荷燃烧三维数值模拟()
分享到:

《东南大学学报(自然科学版)》[ISSN:1001-0505/CN:32-1178/N]

卷:
49
期数:
2019年第3期
页码:
535-541
栏目:
能源与动力工程
出版日期:
2019-05-20

文章信息/Info

Title:
Three-dimensional numerical simulation of variable load combustion of supercritical coal-fired boiler for deep peak load regulation
作者:
袁来运1钟文琪1陈曦1李杰2刘国耀3田万军4
1东南大学能源热转换及其过程测控教育部重点实验室, 南京 210096; 2大唐江苏发电有限公司, 南京 210011; 3南京科远自动化集团股份有限公司, 南京 211102; 4中国大唐集团科学技术研究院有限公司, 北京 100040
Author(s):
Yuan Laiyun1 Zhong Wenqi1 Chen Xi1 Li Jie2 Liu Guoyao3 Tian Wanjun4
1Key Laboratory of Energy Thermal Conversion and Control of Ministry of Education, Southeast University, Nanjing 210096, China
2Datang Jiangsu Power Generation Co., Ltd., Nanjing 210011, China
3Nanjing SCIYON Automation Co., Ltd., Nanjing 211102, China
4China Datang Corporation Science and Technology Research Institute Co., Ltd., Beijing 100040, China
关键词:
超临界锅炉 深度调峰 数值模拟 低负荷稳燃 NOxx排放
Keywords:
supercritical boiler deep peak load regulation numerical simulation low load steady combustion NOxx emission
分类号:
TK224
DOI:
10.3969/j.issn.1001-0505.2019.03.019
摘要:
为解决低负荷运行时燃煤锅炉稳燃性下降和NOxx排放增加的问题,对一台660 MW超临界旋流对冲锅炉在低负荷(20%~60%额定负荷)下不同运行工况进行了三维数值模拟,并研究了低负荷下多种操作参数对锅炉稳燃性和污染物排放的影响.计算与分析结果表明:30%额定负荷运行时投运下层燃烧器,且一次风率为0.2、煤粉粒径为50 μm时,NOxx排放最少;当负荷进一步降低时锅炉稳燃性迅速下降,同时NOxx排放量迅速增加;调整燃烧器运行方式、一次风率和煤粉粒径可以有效改善锅炉低负荷燃烧状况.在负荷低于30%额定负荷的深度调峰运行时,采用2台磨煤机、下层燃烧器运行,并适当降低一次风率和煤粉粒径可以提高燃煤锅炉的低负荷运行能力.
Abstract:
A 660 MW supercritical swirling opposed boiler was simulated under the low loads(rated loads of 20% to 60%),aiming at solving the problem of decreasing combustion stability and increasing NOxx emission of coal-fired boilers in the low load operation.The effects of operating parameters on the combustion stability and the pollutant emission of the boiler were studied.The simulation and analysis results show that NOxx emission reaches its lowest when the lower burners are put into operation at rated load of 30%, as well as the primary air rate is 0.2 and the particle size of the pulverized coal is 50 μm.When the load is further reduced,the boiler combustion stability decreases rapidly,while the NOxx emission increases significantly.The combustion performance can be improved effectively by adjusting the burner operation mode,primary air rate and pulverized coal particle size.It is suggested that two mills and lower burners should be used when the load rate is less than 30% in deep peak load regulation,and the primary air rate and pulverized coal particle size can be appropriately reduced to improve the operating performance of coal-fired boilers.

参考文献/References:

[1] 林俐,田欣雨. 基于火电机组分级深度调峰的电力系统经济调度及效益分析[J]. 电网技术,2017,41(7): 2255-2263. DOI:10.13335/j.1000-3673.pst.2016.2720.
Lin L, Tian X Y. Analysis of deep peak regulation and its benefit of thermal units in power system with large scale wind power integrated[J]. Power System Technology, 2017, 41(7):2255-2263.DOI:10.13335/j.1000-3673.pst.2016.2720. (in Chinese)
[2] 张广才,周科,鲁芬,等. 燃煤机组深度调峰技术探讨[J]. 热力发电,2017,46(9): 17-23. DOI:10.3969/j.issn.1002-3364.2017.09.017.
Zhang G C, Zhou K, Lu F, et al. Discussions on deep peaking technology of coal-fired power plants[J]. Thermal Power Generation, 2017, 46(9): 17-23. DOI:10.3969/j.issn.1002-3364.2017.09.017. (in Chinese)
[3] Zheng Y, Gao X T, Sheng C D. Impact of co-firing lean coal on NOxx emission of a large-scale pulverized coal-fired utility boiler during partial load operation[J]. Korean Journal of Chemical Engineering, 2017, 34(4): 1273-1280. DOI:10.1007/s11814-016-0352-7.
[4] 张广才,周科,柳宏刚,等. 某超临界600 MW机组直流锅炉深度调峰实践[J]. 热力发电,2018,47(5): 83-88. DOI:10.19666/j.rlfd.201802020.
Zhang G C, Zhou K, Liu H G, et al. Practice of deep peak load regulation for a 600 MW supercritical concurrent boiler[J]. Thermal Power Generation, 2018, 47(5): 83-88. DOI:10.19666/j.rlfd.201802020. (in Chinese)
[5] Sun W J, Zhong W Q, Yu A B, et al. Numerical investigation on the flow, combustion, and NOxx emission characteristics in a 660 MWe tangential firing ultra-supercritical boiler[J]. Advances in Mechanical Engineering, 2016, 8(2): 168781401663072. DOI:10.1177/1687814016630729.
[6] Park H Y, Baek S H, Kim Y J, et al. Numerical and experimental investigations on the gas temperature deviation in a large scale, advanced low NOxx, tangentially fired pulverized coal boiler[J]. Fuel, 2013, 104: 641-646. DOI:10.1016/j.fuel.2012.06.091.
[7] Liu Y C, Fan W D, Li Y. Numerical investigation of air-staged combustion emphasizing char gasification and gas temperature deviation in a large-scale, tangentially fired pulverized-coal boiler[J]. Applied Energy, 2016, 177: 323-334. DOI:10.1016/j.apenergy.2016.05.135.
[8] Ti S G, Chen Z C, Kuang M, et al. Numerical simulation of the combustion characteristics and NOxx emission of a swirl burner: Influence of the structure of the burner outlet[J]. Applied Thermal Engineering, 2016, 104: 565-576. DOI:10.1016/j.applthermaleng.2016.05.079.
[9] Yang M, Shen Y Y, Xu H T, et al. Numerical investigation of the nonlinear flow characteristics in an ultra-supercritical utility boiler furnace[J]. Applied Thermal Engineering, 2015, 88: 237-247. DOI:10.1016/j.applthermaleng.2014.09.068.
[10] 钟礼今,邓坚,孙伟杰,等. 低负荷下燃烧器投运方式对锅炉性能的影响[J]. 动力工程学报,2015,35(9): 693-698. DOI:10.3969/j.issn.1674-7607.2015.09.001.
Zhong L J, Deng J, Sun W J, et al. Effects of burner operation mode on performance of the boiler under low load conditions[J]. Journal of Chinese Society of Power Engineering, 2015, 35(9): 693-698. DOI:10.3969/j.issn.1674-7607.2015.09.001. (in Chinese)
[11] Zhao S N, Fang Q Y, Yin C G, et al. New fuel air control strategy for reducing NOxx emissions from corner-fired utility boilers at medium-low loads[J]. Energy & Fuels, 2017, 31(7): 6689-6699. DOI:10.1021/acs.energyfuels.7b00337.
[12] Zeng L D, Fu Z G, Qi W J, et al. Optimal simulation on the variable oxygen for an ultra-supercritical utility boiler[C]//2012 Asia-Pacific Power and Energy Engineering Conference. Shanghai, China. New York, USA:IEEE, 2012: 1-4. DOI:10.1109/APPEEC.2012.6307025.
[13] Zhou H, Yang Y, Liu H Z, et al. Numerical simulation of the combustion characteristics of a low NOxx swirl burner: Influence of the primary air pipe[J]. Fuel, 2014, 130: 168-176. DOI:10.1016/j.fuel.2014.04.028.
[14] Zhang X H, Zhou J, Sun S Z, et al. Numerical investigation of low NOxx combustion strategies in tangentially-fired coal boilers[J]. Fuel, 2015, 142: 215-221. DOI:10.1016/j.fuel.2014.11.026.

备注/Memo

备注/Memo:
收稿日期: 2018-12-03.
作者简介: 袁来运(1991—),男,硕士生;钟文琪(联系人),男,博士,教授,博士生导师,wqzhong@seu.edu.cn.
基金项目: 国家自然科学基金重大资助项目(51390492).
引用本文: 袁来运,钟文琪,陈曦,等.面向深度调峰的超临界煤粉锅炉变负荷燃烧三维数值模拟[J].东南大学学报(自然科学版),2019,49(3):535-541. DOI:10.3969/j.issn.1001-0505.2019.03.019.
更新日期/Last Update: 2019-05-20