[1]王潇猛,钱春香,陈燕强,等.微生物矿化对C3S硬化浆体表层微观结构的影响[J].东南大学学报(自然科学版),2020,50(6):1023-1029.[doi:10.3969/j.issn.1001-0505.2020.06.005]
　Wang Xiaomeng,Qian Chunxiang,Chen YanqiangQu Jun,et al.Effects of microbial mineralization on microstructure of surface layer in hardened C3S paste[J].Journal of Southeast University (Natural Science Edition),2020,50(6):1023-1029.[doi:10.3969/j.issn.1001-0505.2020.06.005]
点击复制

微生物矿化对C3S硬化浆体表层微观结构的影响()
分享到：

《东南大学学报(自然科学版)》[ISSN:1001-0505/CN:32-1178/N]

卷:
50
期数:
2020年第6期
页码:
1023-1029
栏目:
材料科学与工程
出版日期:
2020-11-20

文章信息/Info

Title:
Effects of microbial mineralization on microstructure of surface layer in hardened C3S paste
作者:
王潇猛1; 2; 钱春香1; 2; 陈燕强1; 2; 曲军3; 郭景强3; 刘江虹3
1东南大学材料科学与工程学院, 南京 211189; 2东南大学绿色建材研究中心, 南京 211189; 3西卡(中国)有限公司, 苏州 215121
Author(s):
Wang Xiaomeng1; 2;  Qian Chunxiang1; 2;  Chen Yanqiang1; 2Qu Jun3;  Guo Jingqiang3;  Liu Jianghong3
1School of Materials Science and Engineering, Southeast University, Nanjing 211189, China
2Research Center of Green Building and Construction Materials, Southeast University, Nanjing 211189, China
3Sika China, Suzhou 215121, China
关键词:
微生物矿化;  水化;  微观力学;  表层强化;  孔结构
Keywords:
microbial mineralization;  hydration;  micromechanics;  surface strengthening;  pore structure
分类号:
TU526
DOI:
10.3969/j.issn.1001-0505.2020.06.005
摘要:
为揭示微生物矿化对水泥基材料表层微观结构的影响,采用水泥中主要成分C3S与微生物拌和进行水化-矿化试验.分别采用恒温量热仪和X射性衍射定量分析对C3S硬化浆体水化热及水化程度进行表征,并通过X射线衍射仪、扫描电镜、能谱仪和纳米压痕对硬化浆体中矿化产物及水化产物的钙硅比和弹性模量进行测量.结果表明:矿化作用加速了C3S的早期水化速率,提高了早期水化程度;矿化作用产生了晶型主要为方解石的碳酸钙,并降低了C-S-H凝胶的钙硅比,并使高密度和低密度C-S-H弹性模量不再明显区分;试件表层不同深度处Ca(OH)2和CaCO3含量随深度呈现梯度分布,Ca(OH)2含量随深度逐渐增大,CaCO3含量随深度逐渐减小;矿化降低了试件表层1~6 mm处总孔隙率和连通孔隙率,使平均孔径从70 μm降低至40~50 μm.
Abstract:
To reveal the effects of microbial mineralization on the surface microstructure of cement-based materials, a hydration-mineralization test was carried out by mixing the C3S powder which was the main component of cement-based materials with microorganisms. The thermostatic calorimeter and quantitative X-ray diffractometry(QXRD)were used to characterize the hydration heat and the hydration degree of C3S hardened paste. The calcium-silicon ratio and the elastic modulus of the mineralized and hydrated products in the hardened paste were measured by X-ray diffractometer(XRD), scanning electron microscope(SEM), energy disperse spectroscopy(EDS), and nanoindentation. The results show that the microbial mineralization accelerates the early hydration of C3S and increases the degree of the early hydration. The mineralization produces the calcium carbonate whose crystal type is mainly calcite, reduces the calcium-silicon ratio of the hydration product C-S-H gel, and changes its elastic modulus, so that the elastic modulus of high-density and low-density C-S-H is no longer clearly distinguished. The contents of Ca(OH)2 and CaCO3 at different depths on the surface of the specimen show a gradient distribution with the depth. The content of Ca(OH)2 gradually increases with the depth, and the content of CaCO3 decreases with the depth. The progress of the mineralization reduces the total porosity and the connected porosity in the surface layer of the specimen at 1-6 mm, and the average pore size is reduced from 70 μm to 40-50 μm.

参考文献/References:

[1] Shi X M,Xie N,Fortune K,et al.Durability of steel reinforced concrete in chloride environments:An overview[J].Construction and Building Materials,2012,30:125-138.DOI:10.1016/j.conbuildmat.2011.12.038.
[2] 周会洁,孙维东,孙亚洲.建筑保温与结构一体化技术的应用发展现状[J].长春工程学院学报(自然科学版),2015,16(4):6-10.DOI:10.3969/j.issn.1009-8984.2015.04.002.
Zhou H J,Sun W D,Sun Y Z.The application and development status of integration technology on building insulation and structure[J].Journal of Changchun Institute of Technology(Natural Science Edition),2015,16(4):6-10.DOI:10.3969/j.issn.1009-8984.2015.04.002. (in Chinese)
[3] Baltazar L,Santana J,Lopes B,et al.Surface skin protection of concrete with silicate-based impregnations:Influence of the substrate roughness and moisture[J].Construction and Building Materials,2014,70:191-200.DOI:10.1016/j.conbuildmat.2014.07.071.
[4] Goueygou M,Abraham O,Lataste J F.A comparative study of two non-destructive testing methods to assess near-surface mechanical damage in concrete structures[J].NDT & E International,2008,41(6):448-456.DOI:10.1016/j.ndteint.2008.03.001.
[5] Mechtcherine V.Fracture mechanical behavior of concrete and the condition of its fracture surface[J].Cement and Concrete Research,2009,39(7):620-628.DOI:10.1016/j.cemconres.2009.03.011.
[6] Bentur A,Jaegermann C.Effect of curing and composition on the properties of the outer skin of concrete[J].Journal of Materials in Civil Engineering,1991,3(4):252-262.DOI:10.1061/(asce)0899-1561(1991)3:4(252).
[7] 张健.混凝土防护与修补技术及其特点[J].山西建筑,2017,43(19):96-98.DOI:10.3969/j.issn.1009-6825.2017.19.051.
Zhang J.On technique for concrete protection and maintenance and its features[J].Shanxi Architecture,2017,43(19):96-98.DOI:10.3969/j.issn.1009-6825.2017.19.051. (in Chinese)
[8] 史春亮.混凝土表面耐久性增强剂稳定性和渗透性的研究[D].哈尔滨:哈尔滨工业大学,2006.
　　Shi C L.Research of stability and permeability of concrete surface durability reinforcing agent[D].Harbin:Harbin Institute of Technology,2006.(in Chinese)
[9] Jiang N J,Soga K.The applicability of microbially induced calcite precipitation(MICP)for internal erosion control in gravel-sand mixtures[J].Géotechnique,2017,67(1):42-55.DOI:10.1680/jgeot.15.p.182.
[10] Wiktor V,Jonkers H M.Quantification of crack-healing in novel bacteria-based self-healing concrete[J].Cement and Concrete Composites,2011,33(7):763-770.DOI:10.1016/j.cemconcomp.2011.03.012.
[11] de Muynck W,de Belie N,Verstraete W.Microbial carbonate precipitation in construction materials:A review[J].Ecological Engineering,2010,36(2):118-136.DOI:10.1016/j.ecoleng.2009.02.006.
[12] 陈怀成,钱春香,任立夫.基于微生物矿化技术的水泥基材料早期裂缝自修复[J].东南大学学报(自然科学版),2016,46(3):606-611.DOI:10.3969/j.issn.1001-0505.2016.03.025.
Chen H C,Qian C X,Ren L F.Self-healing of early age cracks in cement-based materials based on mineralization of microorganism[J].Journal of Southeast University(Natural Science Edition),2016,46(3):606-611.DOI:10.3969/j.issn.1001-0505.2016.03.025. (in Chinese)
[13] Park S S,Choi S G,Nam I H.Effect of plant-induced calcite precipitation on the strength of sand[J].Journal of Materials in Civil Engineering,2014,26(8):06014017.DOI:10.1061/(asce)mt.1943-5533.0001029.
[14] Chu J,Ivanov V,Naeimi M,et al.Optimization of calcium-based bioclogging and biocementation of sand[J].Acta Geotechnica,2014,9(2):277-285.DOI:10.1007/s11440-013-0278-8.
[15] 闫潇,刘兴宇,张明江,等.分离自活性污泥的硫酸盐还原菌用于铅锌冶炼渣重金属污染修复[J].微生物学通报,2019,46(8):1907-1916.DOI:10.13344/j.microbiol.china.190283.
Yan X,Liu X Y,Zhang M J,et al.Remediation of heavy metal pollution by sulfate reducing bacteria(SRB)isolated from activated sludge in lead-zinc smelter slag[J].Microbiology China,2019,46(8):1907-1916.DOI:10.13344/j.microbiol.china.190283. (in Chinese)
[16] de Muynck W,Cox K,de Belle N,et al.Bacterial carbonate precipitation as an alternative surface treatment for concrete[J].Construction and Building Materials,2008,22(5):875-885.DOI:10.1016/j.conbuildmat.2006.12.011.
[17] Soin A V,Catalan L J J,Kinrade S D.A combined QXRD/TG method to quantify the phase composition of hydrated Portland cements[J].Cement and Concrete Research,2013,48:17-24.DOI:10.1016/j.cemconres.2013.02.007.
[18] Chen Y Q,Qian C X,Zhou H Y.Characterization methods for the effect of microbial mineralization on the microstructure of hardened C3S paste[J].Advances in Materials Science and Engineering,2020,2020:7869345.DOI:10.1155/2020/7869345.
[19] 张璇,刘娟红.纳米压痕技术在水泥基材料中的研究进展[J].电子显微学报,2015,34(6):530-539.
　　Zhang X,Liu J H.Research progress of the application of nano-indentation to cement-based materials[J].Journal of Chinese Electron Microscopy Society,2015,34(6):530-539.(in Chinese)
[20] 杨飞,刘贤萍,赵永娟,等.连续切片扫描电子显微镜在硅酸三钙研究中的初步应用[J].电子显微学报,2018,37(4):355-360.DOI:10.3969/j.issn.1000-6281.2018.04.009.
Yang F,Liu X P,Zhao Y J,et al.The primary application of serial block-face scanning electron microscopy(SBFSEM)to the study of tricalcium silicate[J].Journal of Chinese Electron Microscopy Society,2018,37(4):355-360.DOI:10.3969/j.issn.1000-6281.2018.04.009. (in Chinese)

相似文献/References:

[1]章春梅.碳酸钙对水泥熟料矿物水化及显微结构特征的影响[J].东南大学学报(自然科学版),1988,18(1):114.[doi:10.3969/j.issn.1001-0505.1988.01.013]
　Zhang Chunmei (Department of Civil Engineering).Influence of Calcium Carbonate on Hydration and Microstructural Characteristics of Cement Clinker Minerals[J].Journal of Southeast University (Natural Science Edition),1988,18(6):114.[doi:10.3969/j.issn.1001-0505.1988.01.013]

备注/Memo

备注/Memo:
收稿日期: 2020-05-27.
作者简介: 王潇猛(1994—),男,硕士生;钱春香(联系人),女,博士,教授,博士生导师,cxqian@seu.edu.cn.
基金项目: 国家自然科学基金重点资助项目(51738003).
引用本文: 王潇猛,钱春香,陈燕强,等.微生物矿化对C3S硬化浆体表层微观结构的影响[J].东南大学学报(自然科学版),2020,50(6):1023-1029. DOI:10.3969/j.issn.1001-0505.2020.06.005.
更新日期/Last Update: 2020-11-20